R-pod Owners Forum Homepage

This site is free to use.
Donations benefit a non-profit Girls Softball organization

Forum Home Forum Home > R-pod Discussion Forums > Podmods, Maintenance, Tips and Tricks
  New Posts New Posts RSS Feed: heater quit working
  FAQ FAQ  Forum Search   Calendar   Register Register  Login Login

Topic Closedheater quit working - Event Date: 03 Apr 2015
 Post Reply Post Reply
Author
Message
  Share Topic Share Topic  Topic Search Topic Search  Topic Options Topic Options
mtbmitch View Drop Down
Groupie
Groupie
Avatar

Joined: 15 Sep 2013
Location: Boise, idaho
Online Status: Offline
Posts: 91 		Direct Link To This Post Calendar Event: heater quit working
    Posted: 04 Apr 2015 at 6:04pm
We got out for our first camping trip of the year this week. Heater worked fine during the evening. Then prior to going to sleep we like to run the heater and warm up the trailer good. Nothing, no fan nothing.
Hot water heater works fine, replaced fuse,still nothing. The thermostat on the wall clicks, that is all. Battery voltage is good. Any suggestions?  09 151 model. Just heater model thermostat, no ac.
thanks
enjoy the fresh air
Back to Top
Luv2Q View Drop Down
Senior Member
Senior Member
Avatar

Joined: 30 Aug 2014
Location: Central TX
Online Status: Offline
Posts: 309 		Direct Link To This Post Posted: 04 Apr 2015 at 7:43pm
Does it not run on propane and, if so, got gas?
John & Teri
Tundra 5.7L V8 / RP 180
E2 WDH / Integrated controller (POS) replaced by Tekonsha P3
Back to Top
techntrek View Drop Down
Admin Group - pHp
Admin Group - pHp
Avatar

Joined: 29 Jul 2009
Location: MD
Online Status: Offline
Posts: 9059 		Direct Link To This Post Posted: 04 Apr 2015 at 8:38pm
He must have gas since the water heater works.   My bet is a bad connection between the thermostat and the heater.  There is a fairly easy step to confirm that - find where the thermostat wires connect to the heater and short across the terminals.  It should start up.
Doug ~ '10 171 (2009-2015) ~ 2008 Salem ~ Pod instruction manual
Back to Top
mtbmitch View Drop Down
Groupie
Groupie
Avatar

Joined: 15 Sep 2013
Location: Boise, idaho
Online Status: Offline
Posts: 91 		Direct Link To This Post Posted: 04 Apr 2015 at 9:13pm
I jumpered the wires at the thermostat and it works as long as the jumper wire is connected. When I remove the jumper wire no matter how high the thermostat is set, it cuts of the propane and shuts the fan down in a minute or so as it normally does on the cool down state.
enjoy the fresh air
Back to Top
CharlieM View Drop Down
Senior Member
Senior Member
Avatar

Joined: 23 Nov 2012
Location: N. Colorado
Online Status: Offline
Posts: 1797 		Direct Link To This Post Posted: 04 Apr 2015 at 9:19pm
So that's the good news. That thermostat has an on/off switch that mechanically stops the contacts from coming together. Check that switch. It's sometimes hard to move. Did I mention cheap junk? After you figure this out and return home consider replacing it with a battery powered electronic thermostat. Lots better.
Charlie
Northern Colorado
OLD: 2013 RP-172, 2010 Honda Pilot 3.5L 4WD
PRESENT: 2014 Camplite 21RBS, 2013 Supercharged Tacoma 4L V6 4WD
Back to Top
techntrek View Drop Down
Admin Group - pHp
Admin Group - pHp
Avatar

Joined: 29 Jul 2009
Location: MD
Online Status: Offline
Posts: 9059 		Direct Link To This Post Posted: 04 Apr 2015 at 9:38pm
Yup, that is good news, since you don't need to run a new wire between the thermostat and heater.
Doug ~ '10 171 (2009-2015) ~ 2008 Salem ~ Pod instruction manual
Back to Top
Tars Tarkas View Drop Down
Senior Member
Senior Member
Avatar

Joined: 14 Jan 2013
Location: Near Nashville
Online Status: Online
Posts: 1446 		Direct Link To This Post Posted: 04 Apr 2015 at 9:45pm
It sure sounds like the thermostat.  Not the heater or the wires between the heater and the thermostat.  The latter was my problem last winter.  That was theoretically a very simple fix but quite difficult from a practical standpoint.

As Charlie said, the eom thermostats are about as cheap as they come.

TT
2010 176
FJ Cruiser
Back to Top
mtbmitch View Drop Down
Groupie
Groupie
Avatar

Joined: 15 Sep 2013
Location: Boise, idaho
Online Status: Offline
Posts: 91 		Direct Link To This Post Posted: 04 Apr 2015 at 10:31pm
thanks for the tips
ordered up a Lux thermostat, got great reviews on Amazon. Camping here is Idaho, the heater is a manditory requirement. We head up to the mountains in the summer and down towards the Snake River in the Spring/Fall. Temps are usually down to mid to high 30's at night. Got to keep the wife happy with the comforts of home.
enjoy the fresh air
Back to Top
mtbmitch View Drop Down
Groupie
Groupie
Avatar

Joined: 15 Sep 2013
Location: Boise, idaho
Online Status: Offline
Posts: 91 		Direct Link To This Post Posted: 14 Apr 2015 at 12:58am
Installed the Lux thermostat the other day, heater works like fine again. Thanks for the troublshooting help.
enjoy the fresh air
Back to Top
techntrek View Drop Down
Admin Group - pHp
Admin Group - pHp
Avatar

Joined: 29 Jul 2009
Location: MD
Online Status: Offline
Posts: 9059 		Direct Link To This Post Posted: 15 Apr 2015 at 7:42pm
win
Doug ~ '10 171 (2009-2015) ~ 2008 Salem ~ Pod instruction manual
Back to Top
 Post Reply Post Reply

Forum Jump Forum Permissions View Drop Down

Bulletin Board Software by Web Wiz Forums® version 9.64
Copyright ©2001-2009 Web Wiz